隨著社會的飛速發展，大興建設各種基礎設施，施工過程中經常用到混凝土攪拌車。 現有的混凝土攪拌車包括攪拌裝置和裝有混凝土的攪拌筒。 在混凝土攪拌車的后部，兩端開口的灰槽與攪拌筒的一端固定連接。
With the rapid development of society, Daxing has built various infrastructure, and concrete mixer is often used in the construction process. The existing concrete mixer includes a mixing device and a mixing drum equipped with concrete. At the rear of the concrete mixer, the ash tanks with openings at both ends are fixedly connected with one end of the mixing drum.
The section of ash chute is generally arc-shaped, and the extension line of ash chute forms a certain angle with the ground to facilitate concrete pouring. However, during the use of the existing ash chute, the concrete is often attached during the dumping process, which is easy to scatter in the bumpy transportation process and pollute the environment.
Moreover, in the process of pulling the concrete to various construction sites in the urban area, due to the road conditions and the operation problems of drivers, the concrete will often be spilled along the way. It not only pollutes the urban road environment, but also forms stubborn cement blocks over time, which are difficult to clean up.
混凝土攪拌運輸車 每輛罐車的后料斗設計有防漏料斗，固定在混凝土攪拌運輸車卸料口正下方，下口可開閉。 在車輛顛簸行駛過程中，每當混凝土從卸料口漏出時，這個小盒子就可以接住拋出的混凝土。 如果滿了，司機只需打開箱下的開關，將箱內的混凝土卸掉即可。 這樣，即使料斗滴下水泥漿，也只會滴入料斗，不會滴落到路面造成污染。 從而解決了混凝土攪拌車沿途漏水的問題。
The rear hopper of each tank car of the concrete mixer truck is designed with a leak proof hopper, which is fixed directly below the discharge port of the concrete mixer truck, and the lower port can be opened and closed. During the bumpy driving of the vehicle, this small box can catch the thrown concrete whenever the concrete leaks from the discharge port. If it is full, the driver only needs to turn on the switch under the box and unload the concrete in the box. In this way, even if the cement slurry drops from the hopper, it will only drop into the hopper and will not drop to the road to cause pollution. Thus, the problem of water leakage along the way of concrete mixer is solved.
混凝土攪拌車防散裝置，現場施工時，灰槽體底板上的插銷打開，混凝土可以流出灰槽體； 運輸時將底板的固定端和開口端封閉，以保證灰槽體中放入混凝土。 即使混凝土攪拌車在路面顛簸，灰槽體上的保護層也能防止混凝土從車上散落。 在混凝土攪拌車運輸過程中，防止混凝土從灰槽中飛散，解決了環境污染問題。
Anti dispersion device of concrete mixer truck. During on-site construction, the bolt on the bottom plate of the ash tank body is opened, and the concrete can flow out of the ash tank body; During transportation, the fixed end and open end of the bottom plate shall be closed to ensure that the concrete is put into the ash tank. Even if the concrete mixer truck bumps on the road, the protective layer on the ash tank can prevent the concrete from scattering from the truck. During the transportation of concrete mixer truck, the concrete is prevented from flying from the ash tank and the problem of environmental pollution is solved.
混凝土攪拌車滴水、滴水主要是由于混凝土攪拌車滿載、運輸過程中制動、紅綠燈起步、顛簸等原因造成的。 混凝土攪拌車出廠前，可以先用隨車自帶的自動高壓噴淋進行清洗，保證車身不帶泥上路。 其次，在攪拌車上安裝防漏斗是防止“灑水滴”的好辦法，提高駕駛員文明駕駛質量，自覺減少攪拌車滴漏，起到凈化路面的作用。
The dripping of concrete mixer truck is mainly caused by the full load of concrete mixer truck, braking during transportation, traffic light starting, bumping and other reasons. Before the concrete mixer truck leaves the factory, it can be cleaned with the automatic high-pressure spray provided with the truck to ensure that the car body does not carry mud on the road. Secondly, installing an anti funnel on the mixer is a good way to prevent "water droplets", improve the civilized driving quality of drivers, consciously reduce the dripping of the mixer and purify the road.
Come to the website for more relevant content http://www.bangping.net/ Consult!